30 08 604 Clean dry lubricating film

/ 9-3 (9400) / 2003 / 0. General / Chemicals / Technical data / 30 08 604 Clean dry lubricating film

Specifications

Gleitmo 300. Silicone wax. Colourless. Free of oil and grease. 400 ml spray can.

Saab application

Invisible lubricating film for lubricating seat belts, rubber, plastic and interior parts.

Packaging

Transport

The product is classified as dangerous goods when transporting. Special regulations apply to packaging, marking and transport, therefore existing lead times cannot be guaranteed.

Directives

The product is extremely flammable. May be hazardous if inhaled after frequent and repeated exposure. May be hazardous to skin in case of prolonged exposure. Pressurized can. Must not be exposed to direct sunlight or temperatures above +50 ° C. Must not be punctured or burned. Also applies to empty can. Do not spray toward open flame or glowing materials. Must be stored separately from materials which may ignite the product - Smoking is prohibited. Avoid inhaling spray mist. Avoid skin and eye contact. Make sure that ventilation is adequate.

Material safety data sheet/

IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Product name	Gleitmo 300 Spray
Chemical name	Silicon wax in naphtha with additive.
Part no.	fl0689
Manufacturer - supplier	Gleitmo Technik AB Varlabergsvägen 6 434 91 KUNGSBACKA Tel: +46 300 333 33 Emergencies: 112
Application	Colourless dry lubricant for textiles etc.

COMPOSITION/INFORMATION ON INGREDIENTS

Ingredient	CAS-no.	Content (%)	FM	FB	FH	R-phrases
Aliphatic naphtha, light	64742-49-0	30 - 60		F+	Xn	11-65
Isopropanol	67-63-0	1 - 5		F	V	313-322-320-11
Propane	74-98-6	10-30
Butane	106-97-8	10-30

Key

FB/FH/FM = Hazard code for fire/health/environment

T+ = Very toxic

T = Toxic

C = Corrosive

Xn = Harmful

Xi = Irritant

V = Moderately harmful

IK = Not subject to labelling

E = Explosive

O = Oxidizing

F+ = Extremely flammable

F = Highly flammable

N = Dangerous for the environment

HAZARDS IDENTIFICATION

Highly flammable. The product can produce vapours that can form a flammable mixture with air at temperatures close to or above the flash point. Heating may cause the container to explode. Defats the skin. Inhalation of high vapour concentrations may have narcotic effect.

FIRST AID MEASURES

Other information	Take off contaminated clothing immediately.
Inhalation	Fresh air, warmth and rest. Seek medical advice.
Skin	Wash skin immediately with soap and water. Moisturize with suitable skin cream. In case of skin irritation, seek medical advice.
Eyes	Rinse the eyes for a long time with plenty of water. Seek medical treatment. Hold the eyelids wide apart.

FIRE-FIGHTING MEASURES

Suitable extinguishing media	Water mist, foam or carbon dioxide.
Unsuitable extinguishing media	Water jet.
Fire/explosions risks	Can produce explosive mixture with air. Aerosol cans can explode in fire.
Special protective equipment for firefighters	Complete protective equipment including respiratory equipment.
Other information	Do not breathe fumes from the fire. Move containers in the vicinity of the fire immediately or cool with water.

SPILLAGE/ACCIDENTAL RELEASE MEASURES

Personal precautions	Do not breathe vapours. Avoid contact with skin and eyes. Use the prescribed protective equipment.
Environmental precautions	Keep the product away from drains, the ground and watercourses. Contact the appropriate authority immediately if the product enters drains, lakes or watercourses.
Methods for cleaning up	Absorb with appropriate absorbent material or collect and deliver to the closest disposal station. Dispose as described under heading 13.
Other information	Risk of explosion. Remove all sources of ignition. Ventilate well. Keep unauthorized persons away from the spillage.

HANDLING AND STORAGE

Special properties and risks	The vapours are heavier than air and collect at floor level and low-lying areas. Flammable vapours that can combine with air to form an explosive mixture are produce at temperatures far below room temperature.
Advice for safe handling	Avoid contact with eyes, skin and clothes. Do not breathe vapours. Use only in well-ventilated areas. Store away from direct sunlight, heat, fire and other sources of ignition. Take precautionary measures against static discharges.
Storage instructions	Store in a dry, well-ventilated place. Keep away from fire and direct sunlight. No smoking. Keep cool and dry, away from food, drink and animal feeding stuffs. Pressurized container: do not expose to temperatures exceeding 50ºC. Heating may cause the container to explode. Store indoors. Avoid cooling below 0ºC.

EXPOSURE CONTROLS/PERSONAL PROTECTION

Chemical identity	Limit
Aliphatic naphtha, light	350 mg/m ³

Control procedures	Use only in well-ventilated areas. Do not smoke, drink or eat when using the product. Good personal hygiene is essential. Wash hands before taking a break and on completion of the work. Wash contaminated clothing before it is used again. The use of a barrier cream is recommended.
Respiratory equipment	A full-face or half-face mask with filter for organic vapours must be used in case of high vapour concentrations or if ventilation is inadequate.
Eye protection	Close-fitting protective glasses with side shields.
Protective gloves	Standard gloves.
Skin and body protection	Work clothes.

PHYSICAL AND CHEMICAL PROPERTIES

Form/state	Aerosol	Odour	Mild odour of hydrocarbons
Colour	Colourless	Solubility	Soluble in organic solvents
Melting point	-150°C (naphtha)	Vapour pressure	240 hPa at +20°C
Density	1.0 g/cm³	Explosion limits	0.8 vol % - 8 vol %
Solubility in water	Insoluble	Autoignition point	+260°C (naphtha)
Boiling point	+57-63°C (naphtha)	Flash point	-33°C

10.

STABILITY AND REACTIVITY

Stability	Vapours can form an explosive mixture with air. Heating above 50ºC may cause the container to explode.
Reacts with	Reacts with strong oxidizing agents.
Hazardous decomposition products	None if guidelines are followed.

11.

TOXICOLOGICAL INFORMATION

Inhalation	Irritating to mucus membranes. May cause headaches and dizziness.
Skin	Frequent or prolonged contact may defat the skin and produce discomfort and dermatitis.
Eyes	Irritating to eyes.
Ingestion	If swallowed, may cause stinging in mouth and throat, nausea and stomach pains. Chemically-induced pneumonia may result from the product entering the lungs due to ingestion or in particular vomiting.
LD50 Oral	> 2000 mg/kg (naphtha) rat.
LD50 Dermal	> 2000 mg/kg (naphtha) rat.
LC50 Inhalation	>190 ml/1/4 hrs LD50, rat.

12.

ECOLOGICAL INFORMATION

Ecotoxicity	Very toxic for aquatic organisms, may cause long-term adverse effects in the aquatic environment.
Other information	Do not empty into sewers or drains.

13.

DISPOSAL CONSIDERATIONS

Disposal considerations

Dispose of product waste as hazardous waste in accordance with regulations. Containers that are completely empty (including propellant) can be sorted as metal containers for recycling.

14.

TRANSPORT INFORMATION

Road (ADR)	UN-no.: 1950 Hazardous goods Marg no.	Class: 2	Label Hazard no.
Rail (RID)	UN-no.: 1950	Class: 2	Label Hazard no.
Sea (IMDG)	UN-no.: 1950 Hazardous goods Class: 2.1 EmS: 2-13	Page MFAG: 311 Label Marine poll: No	Sub. Risk Package group
Air (IATA)	UN-no.: 1950	Class: 2.1	Label

Proper shipping name	Aerosols, flammable.
Other transport information	Keep away from food stuffs. Keep away from sources of heat. Storage temperature max. +50ºC. Forbidden to send by post.

15.

REGULATORY INFORMATION

Pressurized container

Protect from sunlight and do not expose to temperatures above 50°C. Do not pierce or burn, even after use. Do not spray near a naked flame or any incandescent material.

R-phrases	R12	Extremely flammable.
	R18	A flammable/explosive vapour-air mixture can form during use.
	R51/53	Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
	R66	Repeated exposure may cause skin dryness or cracking.
	R67	Vapours may cause drowsiness and dizziness.
S-phases	S2	Keep out of the reach of children.
	S9	Keep container in a well-ventilated place.
	S16	Keep away from sources of ignition - No smoking.
	S23	Do not breathe gas/fumes/vapour/spray (appropriate wording to be specified by the manufacturer).
	S24/25	Avoid contact with skin and eyes.
	S51	Use only in well-ventilated areas.

16.

OTHER INFORMATION

General information	This material safety data sheet is only intended to provide guidance as to safe handling with regard to health, safety and the environment. The information contained in this material safety data sheet is not a specification of the product and must not be considered as a guarantee of any specific properties.
Drafted by	Sven Berlander
Issued	2000-03-20

30 08 604 Clean dry lubricating film

Our Friends