30 15 245 Underseal

/ 9-3 (9400) / 2003 / 0. General / Chemicals / Technical data / 30 15 245 Underseal

30 15 245 Underseal

Specifications

Teroson Terotex 2000 T123 (light). Applied with UBS-spray gun T910, 30 06 798. Rubber and resin-based underseal, can be painted over. 1 litre can.

Saab application

Packaging

Transport

The product is classified as dangerous goods when transporting. Special regulations apply to packaging, marking and transport, therefore existing lead times cannot be guaranteed.

Directives

The product is highly flammable. When used, combustible/explosive vapour-air mixtures can be produced. Must be stored separately from materials which may ignite the product - Smoking is prohibited. Must not be poured down the drain. Take appropriate actions to eliminate static electricity. Make sure that ventilation is adequate.

Material safety data sheet

IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Product name	Terotex 2000 light (T123)
Application	Bitumen-free, durable, elastic underbody coating.
Manufacturer - supplier	Loctite Sweden AB Automotive Aftermarket P.O. Box 8823 SE-402 71 GÖTEBORG Tel: +46 31 750 54 00

COMPOSITION/INFORMATION ON INGREDIENTS

Product contains: solvent, synthetic rubber and resins.

Ingredient	CAS-no.	Content (%)	Hazard symbol/R-phrases	Remarks
Naphtha (petroleum spirit), hydrotreated, light	64742-49-0	30-60	F;R11 Xn;R65 Xi;R38 R67 N;R51/53	Benzene < 0.1%
Naphtha (petroleum), desulphurized heavy	64742-82-1	10-30	R10 Xn;R65 R66 R67 N;R51/53	Benzene < 0.1%
Colophony	8052-10-6	1-5	R43

Key

FB/FH/FM = Hazard code for fire/health/environment

T+ = Very toxic

T = Toxic

C = Corrosive

Xn = Harmful

Xi = Irritant

V = Moderately harmful

IK = Not subject to labelling

E = Explosive

O = Oxidizing

F+ = Extremely flammable

F = Highly flammable

N = Dangerous for the environment

HAZARDS IDENTIFICATION

The product is highly flammable and can ignite after brief contact with a source of ignition.

Adverse health effects	Irritates and defats skin. May cause sensitization. Vapours may cause drowsiness, headache, tiredness, dizziness and nausea.
Adverse environmental effects	The product contains a substance that is harmful to aquatic organisms and may cause long-term adverse effects to the aquatic environment.

FIRST AID MEASURES

Burns	Rinse immediately with water. Remove while rinsing clothing/fabric that is not burnt on. Call an ambulance. Continue rinsing during transport.
Inhalation	The person should rest in fresh air under supervision. In the event of discomfort, seek medical advice and take along this material safety data sheet.
Skin	Take off immediately all contaminated clothing, and wash the effected skin with soap and water. In the even of eczema or other skin irritation: Seek medical advice (take along this material safety data sheet).
Eyes	Rinse immediately with plenty of water for at least 15 minutes. Remove any contact lenses and keep the eyes wide open. If the irritation persists continue rinsing while on the way to hospital. Take along this material safety data sheet.
Ingestion	Rinse the mouth immediately and drink plenty of water, milk or cream. Keep the person under supervision. In case of discomfort, visit a hospital immediately and take along this material safety data sheet.

FIRE-FIGHTING MEASURES

Suitable extinguishing media	Use a foam, carbon dioxide, powder or water mist extinguisher. If exposed to heat, cool with water and remove from the area of fire, if this is possible without entailing risk.
Special protective equipment for firefighters	In the event of firefighting, use respiratory equipment with an air supply.

SPILLAGE/ACCIDENTAL RELEASE MEASURES

Personal precautions	Do not breathe vapours and avoid contact with skin and eyes. Smoking, naked flames and other sources of ignition forbidden. See point 8 regarding personal protective equipment.
Environmental precautions	Avoid release into drains, the environment and the aquatic environment.
Methods for cleaning up	Confine or place absorbent material on the spilt product using sand, earth or other non-flammable material. For disposal considerations, refer to point 13.

HANDLING AND STORAGE

Advice for safe handling	Observe good chemical hygiene. Do not breathe vapours and avoid contact with skin and eyes.
Technical measures	Smoking, naked flames and other sources of ignition forbidden.
Technical information	Mechanical ventilation may be necessary.
Storage instructions	Follow the instructions for flammable fluids.
Storage conditions	Keep well sealed in original packing in a well-ventilated place.

EXPOSURE CONTROLS/PERSONAL PROTECTION

Technical measures

Efficient ventilation must be provided. Limits must not be exceeded and the risk for breathing fumes and spray must be minimized.

Chemical identity	Limit	Type	Comments	Ref.
White spirit	50ppm 300mg/m³	NGV		AFS 2000:3

Respiratory equipment	In case of insufficient ventilation: Use respiratory equipment with gas filter, type A2. For spraying: Use respiratory equipment with combination filter, type A2/P2.
Hand protection	Wear protective gloves. Refer to information from the manufacturer for suitable gloves. The fluid can permeate the gloves. Change gloves often.
Eye protection	If there is a risk of contact with eyes: Wear eye/face protection.
Skin protection	If there is a risk of splashes, wear an apron or special work clothes.
Hygiene measures:	Change soiled clothes.

PHYSICAL AND CHEMICAL PROPERTIES

Form/state	Liquid	Odour	Of petrol
Colour	Grey	Solubility in water	Insoluble
Relative density	0.984 g/cm ³	Boiling point	60-120 °C
Flash point	-17 °C	Other information	Kinematic viscosity at 40°C: >7 mm²/s

10.

STABILITY AND REACTIVITY

Stability	Stable at normal temperatures.
Conditions and material to avoid:	Heating.
Hazardous decomposition products	None at normal temperatures.

11.

TOXICOLOGICAL INFORMATION

Inhalation	Vapours may cause drowsiness as well as headache, tiredness, dizziness and nausea. Vapours and spray may irritate the respiratory system and cause throat irritation and coughing.
Skin	Risk of developing hypersensitivity or triggering existing hypersensitivity. Prolonged exposure may cause redness, irritation and dryness.
Eyes	May irritate and produce redness and stinging.
Ingestion	Irritant. Can be absorbed and cause dizziness, nausea and vomiting.
Prolonged exposure	Frequent repeated inhalation of even low concentrations can produce irritation, tiredness and memory loss and with time permanent damage to the nervous system, including the brain.

12.

ECOLOGICAL INFORMATION

Mobility	The product is insoluble in water. The product contains volatile organic compounds (VOC) that evaporate rapidly from all surfaces.
Degradability	Degradability of product unknown.
Ecotoxicity	The product contains a substance that is toxic to aquatic organisms and may cause long-term adverse effects to the aquatic environment.

13.

DISPOSAL CONSIDERATIONS

Spilt product and waste should be disposed of in accordance with the regulations laid down by local authorities. Dispose of waste as hazardous waste.

Surplus	Leave for controlled disposal, quoting EWC code 20 01 12.
Contaminated packaging	Treat contaminated packaging in the same way as surplus.

14.

TRANSPORT INFORMATION

UN-no.: 1139

Transport name: COATING SOLUTION (White spirit, low aromatic)

Sea (IMDG)	Class: 3.2 EmS: 3-05	PG: II MFAG: 310	MP: Yes
Inland waterways	To be handled locally.
Land (RID/ADR)	Class: 3	Substance number: 5	Letter: b
Air (ICAO/IATA):	Class: 3	PG: II

15.

REGULATORY INFORMATION

Contains	Colophony
Labelling	Highly flammable, Irritant

R-phrases	R11	Highly flammable.
	R38	Irritating to skin.
	R43	May cause sensitization by skin contact.
	R67	Vapours may cause drowsiness and dizziness.
S-phases	S2	Keep out of the reach of children.
	S23	Do not breathe vapour/spray.
	S24	Avoid contact with skin.
	S37	Wear suitable gloves.
	S46	If swallowed, seek medical advice immediately and show this container or label.
	S51	Use only in well-ventilated areas.
Specific Swedish regulations:	None.
National regulations:	European Directives 67/548/EEC relating to dangerous substances and 88/379/EC relating to dangerous preparations (up to and including the 26th adaptation). The National Chemicals Inspectorate's regulations accompanying the regulations (KIFS 1994:12) on the classification and labelling of chemical products, KIFS 1997:5 and KIFS 1999:3 with amendments. The National Chemicals Inspectorate's Chemical Products and Biotechnical Organisms Regulations KIFS 1998:8, with amendments. Publication of the Swedish National Board of Occupational Safety with regulations on occupational exposure limits, AFS 2000:3. Ordinance on dangerous waste (1996:971 with amendments).

16.

OTHER INFORMATION

General information

The user must be given guidance as to appropriate working procedures and be acquainted with the contents of this material safety data sheet. The information contained in this safety data sheet is based on the information that was available at the time of preparation of this safety data sheet and is provided under the assumption that the product is used under the specified conditions and in accordance with the working methods specified on the packaging or in the relevant technical literature. All other use of this product, such as in conjunction with other products or in different processes, is undertaken at the risk of the user.

Issued

2000-10-04 by

DANISH TOXICOLOGY CENTRE

Kogle Allé 2

DK-2970 HØrsholm, Denmark.

Tel: +45 45 76 20 55

Fax: +45 45 76 24 55

30 15 245 Underseal

Our Friends