30 15 914 Protective wax

/ 9-3 (9400) / 2003 / 0. General / Chemicals / Technical data / 30 15 914 Protective wax

Specifications

Teroson protective wax T184. 300 ml spray can.

Saab application

Transparent wax-based anti-corrosion agent for use on exposed areas, for example, in engine compartment.

Packaging

Transport

The product is classified as dangerous goods when transporting. Special regulations apply to packaging, marking and transport, therefore existing lead times cannot be guaranteed.

Directives

The product is extremely flammable. Dehydrates the skin. May be harmful if inhaled after frequently repeated exposure. May be poisonous if ingested. Pressurized can. Must not be exposed to direct sunlight or temperatures above +50°C. Must not be punctured or burned. Also applies to empty can. Do not spray toward open flame or glowing materials. Must be stored separately from materials which may ignite the product - Smoking is prohibited. Avoid inhalation of spray mist. Make sure ventilation is adequate.

Material safety data sheet

IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Product name	Protective wax (T184)
Application	Anti-corrosion agents
Manufacturer - supplier	Loctite Sweden AB Automotive Aftermarket P.O. Box 8823 SE-402 71 GÖTEBORG Tel: +46 31 750 54 00

COMPOSITION/INFORMATION ON INGREDIENTS

Product contains: solvent, propellant, wax and additives.

Ingredient	CAS-no.	Content (%)	Hazard symbol/R-phrases	Remarks
Butane/propane	68475-59-2	30-60	F+;R12
Naphtha (petroleum), desulphurized heavy	64742-82-1	30-60	R10 Xn;R65 R66 R67 N;R51/53	Benzene < 0.1%
Calcium carbonate/sulfonate complex	70024-72-5	1-5	Xi; R36/38

Key

FB/FH/FM = Hazard code for fire/health/environment

T+ = Very toxic

T = Toxic

C = Corrosive

Xn = Harmful

Xi = Irritant

V = Moderately harmful

IK = Not subject to labelling

E = Explosive

O = Oxidizing

F+ = Extremely flammable

F = Highly flammable

N = Dangerous for the environment

HAZARDS IDENTIFICATION

Extremely flammable. Do not spray toward open flame or incandescent material as the pressurized container may ignite. Exposure to a strong heat source may cause the aerosol to explode.

Adverse health effects	Harmful by inhalation and in contact with skin. Vapours and spray may cause headaches, tiredness and nausea. Vapours/spray may irritate the respiratory system. Defats the skin. May irritate the eyes.
Adverse environmental effects	This product contains volatile organic compounds that can contribute to the photochemical formation of ozone. The product contains a substance that is toxic to aquatic organisms and may cause long-term adverse effects in the aquatic environment.

FIRST AID MEASURES

Burns	Rinse immediately with water. Remove while rinsing clothing/fabric that is not burnt on. Call an ambulance. Continue rinsing during transport.
Inhalation	The person should rest in fresh air under supervision. In the event of discomfort, seek medical advice and take along this material safety data sheet.
Skin	Take off immediately all contaminated clothing, and wash the effected skin with soap and water.
Eyes	Rinse immediately with plenty of water for at least 15 minutes. Remove any contact lenses and keep the eyes wide open. If the irritation persists: Visit a hospital and present this material safety data sheet.
Ingestion	Unlikely due to nature of packaging. Rinse the mouth immediately and drink plenty of water or milk. Keep the person under supervision. In case of discomfort seek medical advice and take along this material safety data sheet.

FIRE-FIGHTING MEASURES

Suitable extinguishing media	Use a carbon dioxide or powder extinguisher. If exposed to heat, cool the aerosols with water and remove from the area of fire, if this is possible without entailing risk.
Specific hazards	Exposure to a strong heat source may cause the aerosol to explode.

SPILLAGE/ACCIDENTAL RELEASE MEASURES

Personal precautions	Do not breathe vapours or spray and avoid contact with skin and eyes. Smoking, naked flames and other sources of ignition forbidden. See point 8 regarding personal protective equipment.
Environmental precautions	Do not disopose of aerosol containers in nature.
Methods for cleaning up	Small spillages: Remove small spillages with absorbent material. Dispose of rags and the like that are contaminated with flammable fluids in a special fire-proof container. Large spillages: Remove with non-flammable absorbent material. Refer to point 13 for disposal measures.

HANDLING AND STORAGE

Advice for safe handling	Observe good chemical hygiene. Do not breathe vapours and avoid contact with skin and eyes.
Technical measures	Smoking, naked flames and other sources of ignition forbidden.
Technical information	Mechanical ventilation may be necessary. Emergency sprinklers or other liberal supply of water must be present.
Storage instructions	Follow directions for flammable liquids. Store large quantities and stocks as specified in national regulations for the storage of flammable liquids, etc.
Storage conditions	Keep away from sources of heat and do not expose to high temperatures. Protect from direct sunlight.

EXPOSURE CONTROLS/PERSONAL PROTECTION

Technical measures

Efficient ventilation must be provided. Limits must not be exceeded and the risk for breathing fumes and spray must be minimized.

Chemical identity	Limit	Type	Ref.
Petroleum spirit, hexane	50ppm 180mg/m³	NGV	AFS 2000:3

Respiratory equipment	In case of insufficient ventilation: Wear full-face mask with fresh air supply.
Hand protection	If there is a risk of contact: Wear protective gloves. See glove manufacturer's recommendations for suitable gloves.
Eye protection	If there is a risk of contact with eyes: Wear eye/face protection.
Skin protection	No special measures required.
Hygiene measures:	Change soiled clothes.

PHYSICAL AND CHEMICAL PROPERTIES

Form/state	Liquid	Odour	Of solvent
Colour	Colourless	Solubility in water	Insoluble
Relative density	0.68 g/cm ³	Vapour pressure	3.0 bar at 20°C
Flash point	< 21°C

10.

STABILITY AND REACTIVITY

Stability	Stable under specified storage conditions.
Conditions and material to avoid:	Do not expose aerosols to high temperatures and protect from direct sunlight.
Hazardous decomposition products	None under normal conditions.

11.

TOXICOLOGICAL INFORMATION

Inhalation	Vapours and spray may cause headaches, tiredness and nausea. Vapours/spray may irritate the respiratory system.
Skin	Defats the skin. Prolonged exposure may cause redness, irritation and dryness.
Eyes	Spray may cause irritation.
Ingestion	Unlikely due to nature of packaging. May cause nausea, headache, dizziness and intoxication if swallowed.
Prolonged exposure	Frequent repeated inhalation, even of low concentrations, may lead to irritability, tiredness, memory loss and with time permanent damage to the nervous system, including the brain, and possibly even the liver and kidneys.

12.

ECOLOGICAL INFORMATION

Mobility	Propellant and solvent evaporate.
Degradability	Degradability of product unknown.
Ecotoxicity	This product contains volatile organic compounds that can contribute to the photochemical formation of ozone. The product contains a substance that is toxic to aquatic organisms and may cause long-term adverse effects in the aquatic environment.

13.

DISPOSAL CONSIDERATIONS

Spilt product and waste should be disposed of in accordance with the regulations laid down by local authorities. Do no puncture or incinerate, even when empty.

Surplus	Leave for controlled disposal, quoting EWC code 20 01 22.
Contaminated packaging	Empty aerosol cans completely.

14.

TRANSPORT INFORMATION

UN-no.: 1950

Transport name: AEROSOLS (Butane, Propane)

Sea (IMDG)	Class: 2.1 EmS: 2-13	PG: - MFAG: 620	MP: No
Inland waterways	To be handled locally.
Land (RID/ADR)	Class: 2	Substance number: 5F	Letter: -
Air (ICAO/IATA):	Class: 2.1	PG: -

15.

REGULATORY INFORMATION

Labelling

Extremely flammable

R-phrases	R12	Extremely flammable.
	R66	Repeated exposure may cause skin dryness or cracking.
	R67	Vapours may cause drowsiness and dizziness.
S-phases	S23	Keep out of the reach of children.
	S51	Use only in well-ventilated areas.
Other information	Pressurized container. Protect from sunlight and temperatures above +50°C. Do not pierce or burn even after use. Do not spray against naked flame or any incandescent material. Keep away from sources of ignition - No smoking. Keep out of reach of children.
National regulations:	The National Chemicals Inspectorate's regulations accompanying the regulations (KIFS 1994:12) on the classification and labelling of chemical products, KIFS 1997:5 and KIFS 1999:3 with amendments. The National Chemicals Inspectorate's Chemical Products and Biotechnical Organisms Regulations KIFS 1998:8, with amendments. Provisions of the Swedish National Board of Occupational Safety and Health on occupational exposure limits, AFS 2000:3. Commission Decision of 20 December 1993 establishing a list of wastes pursuant to Article 1(a) of Council Directive 75/442/EEC on waste (94/3/EC). List of wastes pursuant to Article 1(a) of Council Directive 75/442/EEC on waste (EUROPEAN WASTES CATALOGUE).

16.

OTHER INFORMATION

General information

The user must be given guidance as to appropriate working procedures and be acquainted with the contents of this material safety data sheet. The information contained in this safety data sheet is based on the information that was available at the time of preparation of this safety data sheet and is provided under the assumption that the product is used under the specified conditions and in accordance with the working methods specified on the packaging or in the relevant technical literature. All other use of this product, such as in conjunction with other products or in different processes, is undertaken at the risk of the user.

Issued

2000-10-04 by

DANISH TOXICOLOGY CENTRE

Kogle Allé 2

DK-2970 HØrsholm, Denmark.

Tel: +45 45 76 20 55

Fax: +45 45 76 24 55

30 15 914 Protective wax

Our Friends