Checking injector flow capacity
 
  
 
 
  
   
    
     |  | Checking injector flow capacity | 
   
  
  
   
   
   
   
    
     
      
       | 
         
          
           | 
             
              
               |  Warning |  
               | 
                 
                  
                   | 
                     Removal of the fuel pressure regulator involves partial dismantling of the car's fuel system. The following points must therefore be observed in connection with this work:
                     |  
                   | • | Work only in a well-ventilated area! If approved equipment for the extraction of fuel vapour is available, be sure to use it. 
 
 |  
                   | • | Wear suitable gloves! Prolonged contact with fuel can cause skin irritation or dermatitis. 
 
 |  
                   | • | Keep a class BE fire extinguisher near at hand! Be mindful of the danger of sparks caused by short circuits and when connecting and disconnecting leads in electrical circuits. 
 
 |  
                   | • | No smoking anywhere in the vicinity, 
 
 |  
                   | • | Wear protective goggles. 
 
 |  |  
               |  |  |  | 
     
    
    
   
   
    
    
   
   
    
     
      
       | Important | 
      
       | 
         Scrupulous cleanliness is of the utmost importance when working on the fuel rail and injectors. Thoroughly clean the injectors, fuel rail and intake manifold and blow dry with compressed air.
         | 
      
       |  | 
     
    
    
   
   
   
    
     
      
       | 1. | Remove the fuel rail as described in  . 
 
   
 | 
     
    
   
   
    
     
      
       | 2. | Fit a transparent hose onto the nozzle. This hose should be about 40 cm long and have an inside diameter of 15 mm. 
 
 | 
     
    
   
   
    
     
      
       | 3. | Place the end of the hose in a receptacle or measuring flask. 
 
 | 
     
    
   
   
    
     
      
       | 4. | Connect each injector to its proper connector. 
 
 | 
     
    
   
   
    
     
      
       | 5. | Start the fuel pump by connecting diagnostics cable 83 93 886 to the
        
         upper pin
        
        of fuse 8 and the
        
         lower pin
        
        of fuse 19. 
 
 | 
     
    
   
   
    
     
      
       | 6. | Perform a flow capacity test with the diagnostic tool. The diagnostic tool then activates the injector concerned with battery voltage for exactly 30 seconds. 
 
 | 
     
    
   
   
    
     
      
       | 7. | Check the quantity of fuel against the table below. 
 
 | 
     
    
   
   
    
     
      
       | 8. | Change any defective injectors. 
 
 | 
     
    
   
   
    
     
      
       | 9. | Fit the fuel rail and injectors. 
 
 
         
          
          
          
          
          
          
          
          
         
         
          
           | Engine type 
 
 | 
 
 | Flow capacity 
 
 | 
 
 | Maximum permissible difference between injectors 
 
 |  
           | B308E 
 
 | ml/30 s 
 
 | 109 4 
 
 | ml 
 
 | 8 
 
 |  
 
 |